Product ID:FRACTOCRETE 3400
MSDS Date:08/01/1990
FSC:5610
NIIN:00N050208
MSDS Number: BVJNZ

PREMIER REFRACTORIES AND CHEMICALS INC

901 EAST EIGHTH AVE
KING OF PRUSSIA, PA 19406
US

Emergency Phone: 215-337-1100

Info Phone: 215-337-1100

Cage: PREMI

PREMIER REFRACTORIES AND CHEMICALS INC

1569 KING OF PRUSSIA, PA 19406 US

Telephone: 215-337-1100

Cage: PREMI

3); (ALUMINA)

CAS: 1344-28-1

RTECS: BD1200000

Fraction By Weight: >75%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

HYDRAULIC SETTING CEMENT; (CEMENT)

CAS: 12042-68-1

Fraction By Weight: 1-25%

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: TRANSITORY UPPER RESPIRATORY
PHYSICAL IRRITATION. CHRONIC: EXCESSIVE INHALATION ABOVE TLV OF
MINERAL DUST, OVER LONG PERIODS OF TIME, MAY CAUSE INDUSTRIAL
BRONCHITIS, REDUCE BREATHING CAPACITY, AND LEAD TO INCREASED
SUSCEPTIBILITY TO OTHER LUNG DISEASE. CEMENT COMPONENT IN PROD IS
CAUSTIC TO (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EYES AND AN IRRITANT TO UPPER
RESPIRATORY TRACT, AND CAN CAUSE IRRIT TO SKIN ON RPTD/PRLNGD CONT.
EYE: CAUSTIC IRRIT & INFLAMM. SKIN: IRRIT FROM RPTD/PRLNGD CONT.
INHAL: UPPER RESP IRRIT FRO M DEHYDRATION ACTION OF CEMENT ON
MUCOUS MEMBRANES.
Medical Cond Aggravated by Exposure:PRE-EXISTING CHRONIC LUNG
CONDITIONS SUCH AS, BUT NOT LIMITED TO, BRONCHITIS, EMPHYSEMA, AND
ASTHMA.

First Aid:EYE: FLUSH THORO WITH WATER FOR AT LEAST 15 MINUTES. IF
IRRITATION PERSISTS, SEEK MED ATTN. SKIN: WASH WITH MILD SOAP AND
WATER. INHAL: REMOVE TO FRESH AIR. INGEST: CALL MD IMMED .

Extinguishing Media:THIS REFRACTORY PRODUCT IS NON-COMBUSTIBLE. USE
EXTINGUISHING MEDIA APPROPRIATE TO SURROUNDING FIRE.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:CAREFULLY SCOOP UP MATERIAL INTO A SUITABLE
CONTAINER. CLEAN-UP PERSONEL SHOULD WEAR NIOSH/MSHA APPROVED
RESPIRATORY PROTECTION, GLOVES, AND GOGGLES TO PREVENT IRRITATION
FROM CONTACT AND/OR INHALATIO N.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN DRY AREA. PROD CNTNS CEMENT,
WHICH WILL RESULT IN PREMATURE CONSOLIDATION IF EXPOSED TO MOISTURE
DURING STORAGE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN .
Ventilation:PROVIDE ADEQ GEN VENT AND LOC VENT TO CTL MIST &/OR DUST
LEVELS TO NO MORE THAN TLV.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:LONG SLEEVE CLOTHING. ANSI APPROVED
EMERGENCY EYE BATH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PH: 11.5 (10% AQUEOUS SLURRY).

Melt/Freeze Pt:M.P/F.P Text:>3200F,>176
Spec Gravity:2.7(H*2O=1)
pH:SUPDAT
Solubility in Water:SLIGHT
Appearance and Odor:LIGHT GRAY, GRANULAR TO FINE MATERIAL WITH NO
DETECTABLE ODOR
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:PRODUCT IS NON-BIODEGRADABLE, AND DOES NOT
POSESSES CHARACTERISTIC OF A HAZARDOUS WASTE. DISPOSE OF I/A/W
LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.